Forums
New posts
Search forums
What's new
New posts
New profile posts
Latest activity
Members
Registered members
Current visitors
New profile posts
Search profile posts
Log in
Register
What's new
Search
Search
Search titles only
By:
New posts
Search forums
Menu
Log in
Register
Install the app
Install
RAM TRX - TRX-Forum.com
Bronco Raptor - BroncoRaptorForum.com
Forums
Ford Raptor Forums - General Information
Ford Raptor Problems and Questions Forum
2018 transmission/transfer case rattle/whine? (VIDEO)
JavaScript is disabled. For a better experience, please enable JavaScript in your browser before proceeding.
You are using an out of date browser. It may not display this or other websites correctly.
You should upgrade or use an
alternative browser
.
Reply to thread
Message
<blockquote data-quote="thefulllouie" data-source="post: 1870264" data-attributes="member: 56477"><p>I've watched just about every 'noise' video I could find on this forum. (TY community!) None of them sounds like my problem. It doesn't sound like IWE based on where it's coming from and what I've heard/seen in videos I've watched. I've also replaced the the vacuum line with part #FL3Z-3A788-B to be safe. I've also taken off all the skid plates and guards from the entire underbody chasing this noise. No change.</p><p></p><p>Video set up: Mounted my phone on the crossmember between the transfer case and fuel tank under the driver door. Camera is pointed up towards driver's side and facing towards the front slightly. That's the back end of the transfer case in the upper right of frame. Transfer case skid plate in the lower right of the frame. Cross member looking drivers side is that bar in the middle. Drive shaft coming out of transfer case just above the camera out of frame. Gas tank out of frame on the left.</p><p></p><p>Re-creating symptoms: Most noticeable when running gear is cold, however it's still there under harder acceleration even when at operating temp. It happens ''in-between' or when transitioning between shifts. More noticeable 1st - 4th gear. I recreated this video by putting it in manual mode and going back and forth from 1st to 2nd. Easy throttle. I have a ECM and TCM tune from GooseTuned, but this this started before that.</p><p></p><p>Only mods that <em>might </em>have any impact (drive angles maybe, but that's a stretch IMO) are Icon rear leaf springs in back and Eibach level springs up front.</p><p></p><p><strong>Sound happens at approx 9sec, 16sec, 22sec, best heard at 31sec and after (whine/rattle). </strong></p><p></p><p>It's slowly getting louder as time goes on. What does this sound like to you guys? Bearing going bad, low fluid...? I'm at a loss and wanted to turn to this community before I go through the PITA to set up a diagnosis at the dealer.</p><p></p><p>[MEDIA=youtube]aHUx99pZA3w[/MEDIA]</p></blockquote><p></p>
[QUOTE="thefulllouie, post: 1870264, member: 56477"] I've watched just about every 'noise' video I could find on this forum. (TY community!) None of them sounds like my problem. It doesn't sound like IWE based on where it's coming from and what I've heard/seen in videos I've watched. I've also replaced the the vacuum line with part #FL3Z-3A788-B to be safe. I've also taken off all the skid plates and guards from the entire underbody chasing this noise. No change. Video set up: Mounted my phone on the crossmember between the transfer case and fuel tank under the driver door. Camera is pointed up towards driver's side and facing towards the front slightly. That's the back end of the transfer case in the upper right of frame. Transfer case skid plate in the lower right of the frame. Cross member looking drivers side is that bar in the middle. Drive shaft coming out of transfer case just above the camera out of frame. Gas tank out of frame on the left. Re-creating symptoms: Most noticeable when running gear is cold, however it's still there under harder acceleration even when at operating temp. It happens ''in-between' or when transitioning between shifts. More noticeable 1st - 4th gear. I recreated this video by putting it in manual mode and going back and forth from 1st to 2nd. Easy throttle. I have a ECM and TCM tune from GooseTuned, but this this started before that. Only mods that [I]might [/I]have any impact (drive angles maybe, but that's a stretch IMO) are Icon rear leaf springs in back and Eibach level springs up front. [B]Sound happens at approx 9sec, 16sec, 22sec, best heard at 31sec and after (whine/rattle). [/B] It's slowly getting louder as time goes on. What does this sound like to you guys? Bearing going bad, low fluid...? I'm at a loss and wanted to turn to this community before I go through the PITA to set up a diagnosis at the dealer. [MEDIA=youtube]aHUx99pZA3w[/MEDIA] [/QUOTE]
Insert quotes…
Verification
Post reply
Members online
pat247
socal raptor
twoputtbirdie
RaptorAU
17baker
4STUNT
tcm glx
DFS
BIGW0RM
HORN HIGH ACES
SilverGen1
GreenGoblin
mp4par
AlaskanRaptorNome
The Car Stereo Company
SVTNate
DaveInMn
nelsonr103
MurderedOutSVT
970rap
pirates1456
Admin.RealTruck
FordTechOne
jekyll537
MZRaptor72
ljn21
Sean76710
HighwaySentinel
Mike27t
BigA
acharris
Spike Spiegel
PNTitBLK
laramie1pt8t
EagleRaptor
raptorgroyper
Skmon
boxer-werke
hemibob
RHCLLC
briangsxr1000
HeyItsARaptor
awd5906
Jhollowell
Speedhunter
Chuck D
daytona1783
Dan H
Jpro39
NickyF25
... and 30 more.
Forum statistics
Threads
93,174
Posts
1,955,346
Members
56,440
Latest member
jumpcutter
Forums
Ford Raptor Forums - General Information
Ford Raptor Problems and Questions Forum
2018 transmission/transfer case rattle/whine? (VIDEO)
This site uses cookies to help personalise content, tailor your experience and to keep you logged in if you register.
By continuing to use this site, you are consenting to our use of cookies.
Accept
Learn more…
Top